Forced Outages and Energy Losses Due to Failure of Equipment and Auxiliaries in Thermal Power Stations (Capacity 300-350 MW) in India (2012-2013 to 2014-2015) | |||||||||
Areas/Causes of Outages | No. of Outages | MU Loss | %age of Group FO Loss | ||||||
2012-2013 | 2013-2014 | 2014-2015 | 2012-2013 | 2013-2014 | 2014-2015 | 2012-2013 | 2013-2014 | 2014-2015 | |
I. Equipment | |||||||||
A. Boiler | |||||||||
Water Wall Tube Leakage | |||||||||
Super Heater Tube LeakageĀ | |||||||||
Re-heater Tube Leakage | |||||||||
Economiser Tube LeakageĀ | |||||||||
Air Pre-heater Problem | |||||||||
Furnace TroubleĀ | |||||||||
Boiler Operational Problem | |||||||||
(a) Furnace Fire Out/Flame Failure | |||||||||
(b) Furnace Draft Abnormal | |||||||||
(c) Drum Level High/Low | |||||||||
Others | |||||||||
Total Boiler | |||||||||
B. Turbine | |||||||||
Turbine Bearing Problem | |||||||||
Governing/Oil SystemĀ | |||||||||
Turbine Differential Expansion Problem | |||||||||
Turbine Axial shaft /Trust Pad Problem | |||||||||
Turbine Eccentricity/High Vibration | |||||||||
Turbine Rotor/Failure/Damaged | |||||||||
Turbine Control Valve Problem | |||||||||
Condenser Tube Leakage/clean | |||||||||
Main Stream Line Problem | |||||||||
Emergency Safety valve Closure | |||||||||
1Condenser Low VacuumĀ | |||||||||
1H.P. and L.P. Bypass System | |||||||||
1Turnine Misc. ProblemĀ | |||||||||
Total Turbine | |||||||||
C. Generator | |||||||||
Stator /Stator Earth Fault | |||||||||
Gen. Transformer Tripping/Damaged | |||||||||
Rotor/Rotor Earth Problem | |||||||||
Excitation Problem | |||||||||
Gen Cooling System Failure | |||||||||
Seal Oil System Problem | |||||||||
Fire in Turbo Gen. Bushing/Bushing Failure | |||||||||
Generator Bearing Problem | |||||||||
A.V.R. Problem | |||||||||
Generator Protection/Relay Operation Problem | |||||||||
Hydrogen Pressure ProblemĀ | |||||||||
Generator Miscellaneous Maintenance | |||||||||
Total Generator | |||||||||
II. Auxiliaries | |||||||||
A. Boiler Auxiliaries | |||||||||
I.D. Fans Problem | |||||||||
F.D. Fans Problem | |||||||||
P.A. Fans Problem | |||||||||
Milling System /RC Feeder Problem | |||||||||
Pipe and Valve Boiler Side | |||||||||
Boiler Aux. Misc Problem | |||||||||
Total Boiler Aux. | |||||||||
B. Turbine Auxiliaries | |||||||||
Boiler feed Pump Motor Problem | |||||||||
Condensate Pump ProblemĀ | |||||||||
C.W. Pump Problem | |||||||||
Regenerative System Problem | |||||||||
Turbine Pipe and Valves Problem | |||||||||
Desecrator Problem | |||||||||
Turbine Misc. ProblemĀ | |||||||||
Total Turbine Aux. | |||||||||
Total Boiler and Turbine Aux. | |||||||||
III. Other Misc Problem | |||||||||
A. Other Electrical Problem | |||||||||
Unit Aux. Transformer/Station Transformer Problem | |||||||||
General Transformer Tripping/Damaged | |||||||||
H.T/L.T. Supply Problem | |||||||||
D.C. Supply Problem | |||||||||
Switch Yard/Bus Problem | |||||||||
Breaker/Isolator Problem | |||||||||
Electrical Miscellaneous Problems | |||||||||
Total Other Electrical Problem | |||||||||
B. Fuel and Other Misc. Problems | |||||||||
Coal Feeding Problem | |||||||||
Lignite Feeding Problem | |||||||||
Wet/Poor Quality Coal | |||||||||
Fuel Oil Problem | |||||||||
Ash Handling System Problem | |||||||||
E.S.P./Pollution Problem | |||||||||
Fuel Supply and Other Misc. Problems | |||||||||
Other Misc. Problems | |||||||||
Coal Shortage | |||||||||
Total Fuel Supply and Other Misc. Problems | |||||||||
Grid System | |||||||||
Transmission Constraints/Grid Disturbance | |||||||||
Reserve Shut Down /Low Schedule | |||||||||
Total Grid System | |||||||||
Total Miscellaneous |